VHR206CM-90E
VHR206CM-90EG

主要產品：日本東方馬達，泰映TROY減速電機，韓國SPG小功率馬達，
韓國DKM減速電機,CPG晟邦 ...

: /
：蘭工
      :

減速機技術資料：

擺線針輪減速機全部傳動裝置可分為三部分：輸入部分、減速部分、輸出部分。在輸入軸上裝有一個錯位180°的雙偏心套，在偏心套上裝有兩個稱為轉臂的滾柱軸承，形成H機構、兩個擺線輪的中心孔即為偏心套上轉臂軸承的滾道，并由擺線輪與針齒輪上一組環形排列的針齒相嚙合，以組成齒差為一齒的內嚙合減速機構，（為了減小摩擦，在速比小的減速機中，針齒上帶有針齒套）。當輸入軸帶著偏心套轉動一周時，由于擺線輪上齒廓曲線的特點及其受針齒輪上針齒限制之故，擺線輪的運動成為既有公轉又有自轉的平面運動，在輸入軸正轉周時，偏心套亦轉動一周，擺線輪于相反方向轉過一個齒從而得到減速，再借助W輸出機構，將擺線輪的低速自轉運動通過銷軸，傳遞給輸出軸，從而獲得較低的輸出轉速。2擺線減速機的特點
〇高速比和高效率：單級傳動，就能達到1：87的減速比，效率在90％以上，如果采用多級傳動，減速比更大。
〇運轉平穩噪聲低：擺線針齒嚙合齒數較多，重疊系數大以及具有機件平衡的機理，使振動和嗓聲限制在zui小程度。
〇結構緊湊體積小：由于采用了行星傳動原理，輸入軸輸出軸在同一軸心線上，使其機型獲得盡可能小的尺寸。
〇使用可靠、壽命長：因主要零件采用高碳鉻鋼材料，經淬火處理（HRC58～62）獲得高強度，并且，部分傳動接觸采用了滾動摩擦，所以經久耐用壽命長。
擺線減速機的安裝
1、在擺線減速機的輸出軸上加裝聯軸器、皮帶輪、鏈輪等聯結件時不允許采用直接捶擊方法，因該減速機的輸出軸結構不能承受軸向的捶擊力，可用軸端螺孔旋入螺釘壓入聯結件。
2、輸出軸及輸入軸的軸徑選用GB1568-79配合。
3、減速機上的吊環螺釘只限起吊減速機用。
4、在基礎上安裝減速機時，應校準減速機的安裝中心線標高，水平度及其相連部分的相關尺寸。校準裝動軸的同心度不應超過聯軸器所允許的范圍。
5、減速機校準時，可用鋼制墊塊或鑄鐵墊塊進行，墊塊在高度方面不超過三塊，也可用契鐵進行，但減速機校準后應換入平墊塊。
6、墊塊的配置應避免引起機體變形，應按基礎螺栓兩邊對稱排列，其相互距離能足夠使水漿在灌溉時自由流通。
7、水泥漿的灌溉應密實，不可有氣泡、空隙和其他缺陷。
4擺線減速機的使用條件
1、該減速機允許使用在連續工作制的場合，同時允許正、反兩個方向運轉。
2、輸入軸的轉速額定轉數為 1500 轉/分，在功率大于 18.5 千瓦時采用 1000 轉/分。
3、擺線減速機的工作位置為水平位置。在傾斜使用時zui大傾斜角一般小于 15°。在超過 15°時應采用其他措施保證潤滑充足和防止漏油。
4、該減速機的輸出軸不能受較大的軸向力和徑向力，在有較大軸向力和徑向力時須采取其他措施。

HoneyWell Pressure /Level Transmitter STG97L Hart 

HONEYWELL SENSOTEC 43/826-01 PANKAKE LOAD CELL SENSOR

Honeywell DR4200EV1-00-H?P Chart Recorder

Honeywell DR4500 Truline Digital 12” Circular Chart Data Recorder DR45AT-1000

HONEYWELL R7258A 1001 Plug-in Infra-red Amplifier ! NEW

NIB Honeywell PW5K1IC Inligent Controller w/ Manual *Heart of the PW-5000

Honeywell 2000-100-150-1?26 Actuator 120V 45VA ! WOW !

Honeywell U.V. Amplifier R7247C 1001 *NIB*

NORTHERN COMPUTERS / HONEYWELL N-1000-IV ACCESS CONTROLLER PANEL WITH BATTERY 

NEW HONEYWELL MEASUREX 05291202 INPUT OUTPUT CONTACT BOARD I/O MODULE PLC 47494

HONEYWELL SENSOTEC 41/572-03 PANKAKE LOAD CELL SENSOR

Honeywell W7760C-2017 Plant Controller 24VDC ! WOW !

NEW HONEYWELL CC-TAOX01 SER C ANALOG OUTPUT IOTA BOARD

Honeywell 30756718-003 MCU/Output Board

HONEYWELL 51304542-100 I/O CONTROL BOARD KLCN BRAND NEW FACTORY SEALED

Honeywell Omnilight 8M37 Option 2401 Data Acquisition System

GARRETT T04E HONEYWELL 452076-0002S DIVIDET3 TURBO CHARGER NEW HOLLAND TRACTOR

HoneyWell R7248B1028 Flame Safeguard Infrared Amplifier

HONEYWELL C7076A-1007 ULTRAVIOLET FLAME DETECTION SYSTEM DETECTOR OPTICAL 120V

HONEYWELL MEASUREX 05317200 REV B QUAD TACH COUNTER I/F BOARD MODULE CARD 46720

(QDX) Boeing 747 Autopilot Panel 2590624-920 Honeywell 8130

HONEYWELL Q619A 1006 *NICE*

Honeywell 620-0036 POWER SUPPLY MODULE good in condition for industry use

Honeywell Pressure Instrument Druck DPI 701 installed

HONEYWELL TDC3000 4DP7APXIA-322 INPUT CARD

10-HONEYWELL T7984B1055 MODULATING THERMOSTAT NEW FS 

NEW Honeywell CP-EXPIO ComfortPoint BACnet DDC Solution

NEW Honeywell CP-DIO BACnet programmable daigital contr

NEW Honeywell CP-SPC BACnet Small Point Controller

YAMATAKE-HONEY?WELL 30731832-002 RECONDITIONED PC BOARD

HONEYWELL CONTROL R4138C 1018 FLAME SAFEGUARD NEW

HONEYWELL FLAME DETECTOR C7012A1145 ~ NEW IN BOX

Honeywell M9186G-1006 Actuator Motor

HONEYWELL 51400988-100 NSPP 51400988100

HONEYWELL F15-499-053 USPP F15499053

HONEYWELL RA890F-1346 USPP RA890F1346

1 NIB HONEYWELL 30731808-503 30731808503 REGULATOR CARD

Honeywell UDC 6300 IACD PC6301-U-0DP-5?0-0-0E 2 Loop Temperature Control UDC6300

MD-82/83/87/88 AIRCRAFT PART DIGITAL FLIGHT GUIDANCE COMPUTER P/N 4034241-973

Enlarge
Honeywell Dolphin 9700 Wireless Computer (MN9700LPWGC3Q?11E)

NIB HONEYWELL 82408485-001 82408485001 MODULE ELEC CARD

1 set honeywell RM7890 B 1014 BURNER CONTROL S7800 A 1001 RECTIFICATION FLAME AM

HONEYWELL BURNER CONTROL RM7840 M 1017 WITH RECTIFICATION FLAME AMPLIFIER 

Honeywell 30735974-2 Trend Memory PLC 307359742 Honey Well 002 30735974002

honeywell RM7890 B 1014 BURNER CONTROL S7800 A 1001 SET

HONEYWELL 620-0041 POWER SUPPLY 6200041 NIB FS

SET honeywell RM7890 B 1014 BURNER CONTROL S7800 A 1001 ultraviolet R7849 A 1023

HONEYWELL BURNER CONTROL RM7888 A 1019 MODULE RM7888A1019

new Honeywell RM 7890C1005 Automatic Primary Burner Control RM7890 C 1005

HONEYWELL PM7700A 1067 PROGRAM MODULE *NEW IN A BOX*

1 set honeywell RM7890 B 1014 BURNER CONTROL S7800 A 1001 R7847 B 1031 KEYBOARD

Honeywell RM7895A-1014 Airflow Switch NEW

HONEYWELL RA890G1229, FSG UV PROTECTORELAY NIB!

FF-SB14R08K-S2 HONEYWELL

2650 Honeywell BC7000L Microcomputer Burner Control Sy

Honeywell K2LCN-2 Ass 51401551-200

HONEYWELL BURNER CONTROL RM7885A 1015 MANUAL START NIB

HONEYWELL DC300K-E-2B3-2?1-0000-0 USPP DC300KE2B32100?00

HONEYWELL M7284C1000 120V Non-Spring Return MODIV MOTOR

HONEYWELL STG644-E1G-000?0 USPP STG644E1G0000

HONEYWELL 51401291-100 LLCN FW51120492 PC BOARD MODULE CARD TESTED WORKING 41299

HONEYWELL T7400B-1002 NSFP T7400B1002

Honeywell 30731814-4 DCS board TDC 2000 or 30731814

Honeywell R7249A1003 AMPILIFIER UV FLAME CURRENT LEVELS 3SEC 286R

HONEYWELL UV FLAME DETECTOR C7061A 1038 ~ New in box

HONEYWELL 4DP7APXDH-233 USPP 4DP7APXDH233

HONEYWELL VA30102CO-NET NSPP VA30102CONET

HONEYWELL M9484F-1007 NSFP M9484F1007

HONEYWELL 14507287-002 USPP 14507287002

HONEYWELL M9184F-1034 NSFP M9184F1034

HONEYWELL W7751G-1003 USPP W7751G1003

HONEYWELL 78SD29-4-H USPP 78SD294H

HONEYWELL DC5061-0-1000-?100-00-0211 USPP DC506101000100?00

*NEW* HONEYWELL WEBSTAT CONTROLLER W7350A1000 WITH THE BOX

HONEYWELL STD624F-B10-00?000-0+XXXX NSFP STD624FB100000?00

HONEYWELL W7020E-1044 USPP W7020E1044

HONEYWELL XL50-MMI USPP XL50MMI

HONEYWELL M7284Q-1082 NSPP M7284Q1082

HONEYWELL R7247C 1001 U.V. AMPLIFIER R7247C1001 NEW 

Honeywell 51304362-100 Low Level Analog Mux TDC 3000

New Honeywell 1EN114N119 Microswitch 

HONEYWELL/MICR?OSWITCH 942-M3A-2D-1G1 POSITION RELAY/TRANSDUC?ER ***NIB***

Honeywell NC-NSEK Two-Door Expansion Kit

Honeywell 22016 (Pack of 24) Ssec Terminal Block - 

HONEYWELL 14004078 001 AIR-O-MOTOR ACTUATOR 686886-9

HONEYWELL VP1312-12-B-2-?BL USPP VP131212B2BL

Honeywell Transmitter With Capillarie/Fla?nge

Honeywell/Micr?o Switch FE-MLS5RB Photoelectric FEMLS5RB Micoswitch

Honeywell/Leed?s & Northrup 074419 Control Board L&N

Honeywell/Leed?s & Northrup 228261 Control Board L&N

SET OF HONEYWELL DETECTOR 3 3LC72 LIGHT CURTAINS 72''

Honeywell 51197103-111 Retrofit for 19" Touchscreen 51197103111

NEW HONEYWELL PURPLE PEEPER C7012 (C7024) FLAME DETECTOR 120 VAC FREE SHIPPING

NEW HONEYWELL CONTROL C7061 Flame Detector PURPLE PM120933-T4 CAV.2 C7061A 1038

HONEYWELL RM7838 B 1013 BURNER CONTROLLER

Yamatake Honeywell 82408458-002 BM-A 82408461-001

Honeywell FGS Programming Relay 120V R4795A 1016 ! WOW

HONEYWELL 80366195-100 USPP 80366195100

HONEYWELL UDC3300 CONTROLLER, DC330B-EE-003-?20-000000-E

HONEYWELL 14503202-003 USPP 14503202003

HONEYWELL MODUTROL IV MOTOR M7285C1009 (M7285C1009)

Honeywell M6285A-1005 Rotary Actuator

Honeywell RA890F 1270 FSG Protectorelay - New, No Box

HONEYWELL 51196989-001 NSPP 51196989001

HONEYWELL 9674201 **

HONEYWELL R7515A-1059-3 USPP R7515A10593

HONEYWELL R7516B-1049-17 USPP R7516B104917

HONEYWELL R7515A-1059-16 USPP R7515A105916

HONEYWELL 14006700-52111?0 NSFP 14006700521110

HONEYWELL 14507641-001 NSFP 14507641001

HONEYWELL 30682531 USPP 30682531

HONEYWELL STD624D-A10-50?26 USPP STD624DA105026

HONEYWELL 30750218-003 USPP 30750218003

HONEYWELL M9194D-1003 FNFP M9194D1003

HONEYWELL M7284C 1000 *NEW IN BOX* 

Honeywell Y8835A1028 EnviraZONE 3-Zone Zoning Panel Kit

HONEYWELL 14005680-08959?2 NSPP 14005680089592

HONEYWELL 51404170-125 USPP 51404170125

HONEYWELL STD904-E1A-000?0-1C.SB.SM.ZS-?B77P NSFP STD904E1A00001?CS

RM7840M1017 HONEYWELL FLAME CONTROLLER

Honeywell Ademco Vista 20P With (2)6280W Touchscreen Keypad Ver 9.12

Honeywell Ademco Vista 20P With (1)6280W And (1)6280S Touchscreen Keypad Ver 9.1

Honeywell Ademco Vista 20P With (2)6280S Touchscreen Keypad Version 9.12

HONEYWELL 621-0012-R USPP 6210012R

HONEYWELL TRANSMITTER MGG14C-CB4G 120V VAC 13W W/ KID1B-0002PL21?SY-XX FLOW 41657

HONEYWELL MGG14C-CA4H-XA?XX-SH-A MAGNEW 3000 PLUS SMART CONVERTER FLOWMETER 41376

Yamatake Honeywell 82408485-001 SBLA-III or 82408485

HONEYWELL 30750218-010 USPP 30750218010

HONEYWELL V4055A-1312 NSFP V4055A1312

HONEYWELL STR14G-11A-1B0?CAABC400K-MB.1?C-B77P ST3000 ***NNB***

HONEYWELL 51205554-005 NSFP 51205554005

HONEYWELL 4DP7APXIA-222 USPP 4DP7APXIA222

HandHeld Imageteam 4820 Honeywell 2D Wireless BarCode Scanner

C7012E1104 HONEYWELL

C7012E11047 HONEYWELL

HONEYWELL CXS 0040 HP VARIABLE FREQUENCY DRIVE

HONEYWELL IC697PWR711H POWER SUPPLY

HONEYWELL W7400A1001 PROGRAMMABLE SZ LOGIC MODULE

Honeywell Trend Mini Trend V5

Honeywell DI-4001 Weather Radar Indicator

Honeywell RA890H 1052 2 Flame Response Safety Switch

Honeywell 3820 Cordless Linear Scanner and Base

Honeywell Temperature Controller DC300K-E-000-2?0-0000-0 (6178)

HONEYWELL W7100A1053 MICROPROCESSOR AIR CONTROL NEW 

BEARING BALL * 9-539 / 39539 (MFR Honeywell / Timken)

HONEYWELL CHART RECORDER DR4200 120V DR4200GP2-00-G?G00000 DR4200GP200GG0?0000

Honeywell Microswitch FF-LS082802362 Light Curtain NEW!

Honeywell Microswitch FF-LS16141962 Light Curtain NEW! 

YAMATAKE HONEYWELL 82408667-005 MEMORY MODULE

HONEYWELL BPWU600B-001 POWER SUPPLY 120V, 12A, 60Hz, BPWU600B001 
HONEYWELL C7012E1104 FSG SELF CHECK UV SENSOR FLAME DECT. 3/4 MTG

HONEYWELL R7247C1001 FLAME RESPONDER 2-4 SEC. NSN: 5961-01-170-48?90

Leeds & Northrup / Honeywell

Honeywell y8835A1028 zoning control w/ 3 Stats

NIB HONEYWELL 620-3691 RACK

NIB HONEYWELL FE-MLS5RB PHOTOELECTRIC CONTROL INFRARED

HONEYWELL 82408485-001 PC BOARD SBLA-III YAMATAKE

HONEYWELL UDC3000 UDC300C-0-2A0-?20-0000-0 NEW 

HoneyWell C7012A 1202 Purple Peeper UV Flame Detector

NEW HONEYWELL RM7838 B 1013 BURNER CONTROL RM7838B1013

Honeywell DR4500 Truline Chart Recorder - Controller DR45AT1100-40-?000-500P00-0

Honeywell HHP Dolphine 7450 Wireless Barcode Scanner

HONEYWELL 51453568-003 ANALOG / DISCRETE OUTPUT MODULE

Honeywell Proportional Motor Model: M9184C 1031 (M9184C1031)

Honeywell Pressure Transmitter / Transducer STD930 

Honeywell FH8000A2020 TrueCLEAN Enhanced Whole-House Air Cleaning System

Honeywell FH8000A2520 TrueCLEAN Enhanced Whole-House Air Cleaning System

Honeywell R7795B1009 Flame Safety Control ! WOW !

Honeywell Video HRDP4D50 DVR BRAND NEW 

HONEYWELL / MEASUREX 09436000 CCP PERSONALITY UNITEC PROCESSOR BOARD 61142

HONEYWELL MEASUREX 05345901 REV.E HLAIP HIGH LEVEL AIP CONTROL BOARD 59371

HONEYWELL C7061A 1046 UV FLAME DETECTOR 1" PIPE **NEW**

Honeywell RA890F1429 Flame Safety Relay NIB

HONEYWELL MEASUREX UNITEC 05345102 REV E PROCESSOR BASEBOARD ASSY MODULE 50579

OFFER & WIN HONEYWELL TC-PPD011 BATTERY EXTENSION MODULE

HONEYWELL NXS0100A1003 10HP DRIVE 3PH W/O DISPLAY ***XLNT***

Honeywell V9055A1055 (V9055A1055) Fluid Power Actuator

HONEYWELL 4DP7APXDH233 DATA HIGHWAY PC BOARD ***NIB***

Honeywell 620-0072 Loop Processor 6200072 **XLNT**

HONEYWELL 30731739-002 NSFP 30731739002